M. Natalia, A. Shoiful, Ikbal, S. Hasiany, F.E. Priyanto, Arifudin, Setiyono, R. Noorain
Palm oil mill effluent (POME) contains very high organic compounds that must be treated before being discharged into the environment. Pond technology has been widely used for the treatment of POME; however, it requires a huge area of land. Down-flow hanging sponge (DHS) reactor has shown a high pollutant removal efficiency, less energy, and land area requirement. This study aimed to investigate the performance of a series of anaerobic (R3) and aerobic (R4) DHS reactors in treating POME. The reactor was continuously supplied with POME in three different phases for 165 days. The COD loading rate was set at 3.06, 6.12, and 12.24 kg-COD/m³·day in Phase 1, Phase 2, and Phase 3, respectively. Hydraulic retention time (HRT) was set at 47 min and 50 min, in R3 and R4, respectively. The reactors showed good performance for pollutant removal efficiency, especially COD. In Phase 1, the average COD removal rate was 2.68 and 0.27 kg-COD/m³·d in R3 and R4, respectively. In Phase 2, when the COD loading rate was increased, the average COD removal rate achieved 4.12 and 1.53 kg-COD/m³·d in R3 and R4, respectively. In Phase 3, the COD loading rate was doubled to 12.24 kg-COD/m³·day and the average COD removal rate of 5.81 and 2.90 kg-COD/m³·d was achieved in R3 and R4, respectively. During operation, the concentration of nitrate fluctuated in R4, which indicated that nitrification had occurred. Phosphate could be reduced in R3, but only a small portion could be removed in R4. Total suspended solids (TSS) could be effectively removed in R4. These results revealed that a combination of anaerobic-aerobic DHS reactors showed good performance in removing pollutants such as COD and TSS. Therefore, DHS technology can be used as a polishing treatment for treated POME. © Published under licence by IOP Publishing Ltd.
Environmental Engineering, Department of Infrastructure and Regional Technology, Sumatera Institute of Technology, Lampung Selatan, 35365, Indonesia; Research Center for Environmental and Clean Technology, National Research and Innovation Agency (BRIN), PUSPIPTEK, Tangerang Selatan, Serpong, 15314, Indonesia; Malaysia Institute of Chemical and Bioengineering Technology, University Kuala Lumpur, Kawasan Perindustrian Bandar Vendor Taboh Naning, Alor Gajah, Melaka, 78000, Malaysia
Research at a Glance
Register to unlock
Topics & SDG Alignment
Register to unlock
Collaboration
Register to unlock
Author Profile (Selected)
Register to unlock
References Overview
Register to unlock
Journal & Source
Register to unlock
Metadata & Integrity
Register to unlock